HELP       LOG IN
 
 
 
 
 
 
 
 
CALIFORNIA CONVERTERS Certification  |  EPA Policy  |  CARB OBDII  |  Warranty  |  California Converter Laws    

*NEW CALIFORNIA CATALYTIC CONVERTER LAW
   Effective January 1, 2009
  • NEW LAW DATE:  Effective January 1st, 2009
  • LAW CODE:  California Vehicle Code Section 27156 & 38391
  • WHO THE NEW LAWS EFFECT?: Manufacturers, Installers and Resellers of New Aftermarket Catalytic Converters.
General Guidelines:

CALIFORNIA VEHICLE APPLICATION CATALOG INSTRUCTIONS - For California Application look-up it will no longer be based upon G.V.W. (Gross Vehicle Weight) and engine size. Catalytic Converter Application look-up for California ONLY is the only approved method for determining the correct part number. It is illegal in California to select a catalytic converter for installation based solely on vehicle weight, engine size, physical shape, size, configuration or pipe diameter.

For California non-OBD-II vehicles, the application list will identify the vehicle based on the categories below:

(PC-1): Passenger cars with single or dual exhaust systems with one catalytic converter per exhaust bank.
(View Diagram)
(T-1): Light-duty or medium-duty trucks with single or dual exhaust systems with one catalytic converter per exhaust bank.
(View Diagram)
(PC-2): Passenger cars with single or dual exhaust systems with two or more catalytic converters per exhaust bank.
(View Diagram)
(T-2): Light-duty or medium-duty trucks with single or dual exhaust systems with two or more catalytic converters per exhaust bank.
(View Diagram)


DETERMINING SINGLE AND DUAL CONFIGURATIONS
- A single configuration refers to vehicles with an OEM catalytic converter configuration consisting of a single catalytic converter per bank.


A dual configuration refers to vehicles with an OEM catalytic converter configuration with two or more catalytic converters inline per bank.


To learn more about California Part#'s click HERE.


IDENTIFYING A NEW CALIFORNIA AFTERMARKET CATALYTIC CONVERTERS - As of January 1st, 2009, what you need to look for to ensure you are selling, buying or installing California LEGAL catalytic converters:

The body should be clearly labeled with the following:
  • A.R.B.- EO Number: (example: D-193-88)
  • Part Number: (example: 34015)
  • Date Code: (example: 0109)
  • Directional Flow Arrow
  • 1/2" Tall Numbers
  • Must Be Visible From 5ft. Away


    New California Aftermarket Catalytic Converters
    As of January 1st, 2009, What You Can and What You Cannot Sell/Required:

    *Please Note - Installers may not install a new aftermarket catalytic converter in a vehicle unless all of the following conditions are met:

    (A) The vehicle is specifically included in the vehicle application list for which the new aftermarket catalytic converter has been exempted;

    (B) The vehicle is more than 7 years old or has more than 70,000 miles on its odometer;

    (C) The vehicle is beyond the coverage of the OEM catalyst warranty period (which can vary from 7 years or 70,000 miles to as high as 15 years or 150,000 miles).2 Installers may reference the vehicle owner’s manual/warranty booklet or contact the vehicle manufacturer or its representative to verify the applicable OEM catalyst warranty;

    (D) The vehicle has a legitimate need for replacement of the existing converter that has been established and documented by the installer on the repair invoice. If the OEM converter is present, the installer must make a determination that it is not functioning properly before acting to replace it;

    (E) The exempted new aftermarket catalytic converter is installed in the same location as the OEM catalytic converter it is designed to replace. The front face of the installed catalytic converter shall be no more than three inches further upstream or downstream in the exhaust from where the front face of the OEM catalytic converter was located. The installation may not alter the location, position, or orientation of oxygen sensors upstream and downstream of the catalytic converter(s);

    (F) The exempted new aftermarket catalytic converter is installed on a one-for one catalytic converter (not substrate) basis;

    (G) The exempted new aftermarket catalytic converter is installed with all other required catalytic converters (no consolidation of catalytic converters, nor addition of extra catalytic converters is allowed); and

    (H) A warranty card has been filled out by the installer, signed by the customer, attached to the repair invoice, and a copy returned to the manufacturer.

    (I) Installers shall keep documentation regarding the installation of the new aftermarket catalytic converters including all of the above information. This documentation shall be made available to ARB or its representative as provided for in title 13, section 2222(b)(8). All such records shall be maintained for four years from the date of sale or installation of the catalytic converter.




    RELATED LINKS:

  • PRODUCTS

    Exhaust Systems
    Catalytic Converters
    Mufflers
    Diesel
    Tips
    Racing Parts
    Pipes and Tubing
    MF Gear/Apparel
    SUPPORT

    Company Profile
    Contact Us
    About Us
    Facilities
    Job Opportunites
    Customer Testimonals
    Warranty Info
    DEALERS

    Customer Login
    RMA Request
    Dealer Signup
    MORE

    Latest News
    Team MagnaFlow
    Events Calendar
    MagnaFlow Videos
    Project Vehicles
    Fun Downloads
    MF Decals
    FREE EXHAUST
    EMAIL SIGN-UP
      
    continent:   language:
       
     
     

    WE'VE GOT THE QUALITY, POWER AND SOUND YOU'RE LOOKING FOR!
    MAGNAFLOW EXHAUST PRODUCTS FOR
    DIESEL & GAS TRUCKS AMERICAN MUSCLE CARS EURO/SPORT COMPACT
    © 2014 MagnaFlow. All rights reserved. ISO 9001:2008 Certified - Registered Since 2000